|
SMALLEST PREMIUM
SPEAKERS Development Inside
Story |
In spring 2007,
Hasehiro attacked the development of the smallest high end
audio system, diversification of a sound source,
the housing situation in urban community. He didn't have
a smaller driver on hand. |
|
Hasehiro found some 4cm drivers in the
catalog, and he got a fit-looking driver. It's Fostex 40A02
using alnico magnet; the middle of the photo. But
it was smaller-than-expected driver and the cone
diameter was only 32mm. It's like bean driver of
0.2W. It's hardly possible that it can play low-pitched
sound. |
Hasehiro lost a sense of expectancy before
playing it. Fostex 40A02 couldn't push a sound out of
the enclosure opening due to lack of power. If
it's 5cm driver...? |
Hasehiro
got Tang Band W2-852SF; the right side of the
photo. First, Hasehiro drove it by a tube amp of 2W and
it's PC sound source. It was not bad. Next, he
drove it by 300B. Modestly-bass came out from
the enclosure opening. |
|
I can make it if mount 5cm driver on it, he
thought. |
Hasehiro wanted to make the smallest
enclosure at 18cm high. He made a change in a
design of enclosure over and over again. But it was
unreasonable target for Hasehiro backloaded
system. Eventually, it ended with a compromise that it is
A5-sized 23cm high. In the
trial stage, Hasehiro chose newly-developed
special "Hall Tone" coating for redeem thin
enclosure.
|
Furthermore, outstanding difficulty is
5cm full-range speaker driver. Hasehiro tested a wide
range of highly- reputed speaker drivers from one
minute to the next, but they could not get to
the backloaded level. They lack the power of the
magnet. Hasehiro was on the verge of giving up. |
|
Finally, Hasehiro obtained another one and tested
it; the bottom both ends in the photo. The speaker driver
has sufficient power. So Hasehiro decided that it's
available for backloaded horn system. Hasehiro made the
special "Hall Tone" painted prototype and exhibited it at the
Hasehiro listening event in Nihonbashi in the
fall of 2007. The powerful sound was extremely
well received. Hasehiro aimed to
commercialize that. |
Further
Outstanding Difficulty |
Hasehiro found a good speaker driver
and the prototype got a favorable reception from a lot of
listeners. So, He was aiming to commercialize the smallest
high end back loaded horn speaker soon. Then
one day Hasehiro's agent brought small loudspeakers for
PC and he told Hasehiro "I give you this famed
loudspeakers, please surpass the acoustic quality". The
agent suggested develop iPod-enabled smaller backloaded
horn speaker to Hasehiro early on. This famed
loudspeaker mounted weedy 5cm speaker driver. Hasehiro
listened unwillingly to the sound for repay his
kindness. What an incredible sound! Of course it's no
dynamism like backloaded horn system, but the sound of
musical instruments and vocal have an
indescribable atmosphere. Without a doubt, that's a wolf
[hi-fi sound] in sheep's clothing [small in
size]. Backloaded prototype's sound is better if it is a
stomping rock music. However, this famed loudspeaker's
sound is better if it is a quiet classic and ballad. The
backloaded prototype can't even equal the nuance of music
and mood of this famed loudspeaker. Hasehiro thought this
famed loudspeaker has secrets from the box of a
purpose-built structure, but above all else, the speaker
driver seemed to provide excellent performance. It
seemed to him that the speaker drivers are
performing music from the larger diameter than its
diaphragm. Hasehiro detached the speaker drivers
from this famed loudspeakers, and he outfitted the
enclosures of the backloaded prototype with the speaker
drivers, it not only energy, dynamism but also delicate
goodly tone that it knock the bottom out of existing
sound of 5cm drivers, certainly that was target
tone. That's the most appropriate best speaker
driver! Hasehiro can't go back any
more. |
|
|
However, Hasehiro
did not know the speaker driver and that origins. He took
it after much ado and he ordered the speaker driver
from the manufacturer. But it was a different sound
in spite of the same model of the speaker driver. The
agent had heard that Mr.Hiroaki Otani tuned to the
speaker driver and so he called Mr.Otani to ask about the
tuning process. Naturally, Mr.Otani refused absolutely
because of a trade secret. That's true, but both
drivers are too different in spite of the same looks. Hasehiro
thought I can't reach that moving piece of sound
to many people if quickly go quiet and
obedient. Hasehiro bounced own passion off
Mr.Otani, I want to make the world's highest small audio
speaker. Hasehiro could acquire the tuning know-how by
Mr.Otani.
|
Hasehiro tuned the speaker driver more than
once. In November 2007, he could recreate that emotional
sound. The smallest premium speaker reproduces the
atmosphere and the echo of concert hall and also the space
of stage even it's about 30cm distance between both
speakers. That's not forced to compromise speaker such as
patience of mini. You can enjoy the own character
such as the magnificent orchestra, the shining string
music, the hot jazz and the enthusiasm of
rock. In January 2008, Hasehiro Audio introduced
an entirely new type of the speaker system -
UMU-131XS. Hasehiro Audio gave a name "Hasehiro Premium" to the speaker series of
sally forth into the world and Hasehiro Audio
decided promptly that UMU-131XS is the first production
of "Hasehiro
Premium"
|
Stand out from all the others by full
licensing of technology from a speaker tuner \ Mr.Hiroaki
Otani.
Performed optimization tuning to 5cm
full-range speaker driver of flat characteristics from 150
to
20kHz. | |
visit the other development
inside stories by clicking on the banner. |
Super Sound Coating Compound |
Ionic Record Stabilizer |
the world's first Hybrid Horn |
See-through Horn |
under construction |
For Jazz Audio Fans
Only |
Thank
you for coming to the sound reproducing world. Copyright ©
2009-2014 TelaWorks Corporation, All Rights
Reserved. | |